- Mon - Sat 8:00 - 18:00
- [email protected]
- 0086-21-58386256
Researchers agree that waste quarry dust at 20% (Imran and Muthu, 2018) sand replacement can increase the compressive and flexural strength of concrete by 10% and splitting tensile strength by 15%
It was deduced from those studies that partial replacement of sand with quarry dust without the inclusion of other admixtures resulted in enhanced workability in the concrete mixes [2-3], but …
Issue: 2 March-April 2017 concluded that The partial replacement of sand in concrete has been done using in a mix proportion M20 of 1:1.94:3.17 which gives the significant improvement in strength. James Alexander. ... Quarry Dust is made when huge rocks are broken down into small particles to construction in quarries. It is like sand but
Effect of Quarry Dust as Partial Replacement of Sand in Concrete. PoonamA. BishnoiM. Bala. Engineering, Environmental Science. 2015. The reduction in the sources of natural sand and …
The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials. Granite fines or …
Crushed gravel sand The fine aggregates serve the purpose of filling all the open spaces in between the coarse particles. Thus, it reduces the porosity of ... In this project work we used quarry rock dust as a partial replacement of fine aggregate and fly ask replaced by cement. The ingredients are used in proper proportion. Also the cement and
P.Sri Lakshmi Sai Teja, S.Kanakambara "PARTIAL REPLACEMENT OF SAND WITH QUARRY DUST IN CONCRETE International Journal of Innovative Technology and Exploring Engineering (JITEE) ISSN: 2278-3075, Volume-2, Issue-6, 4. G.Balamurugan, Dr.P.Perumal(December 2013)"USE OF QUARRY DUST TO REPLACE SAND IN …
partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50%. The compressive strength of concrete cubes are obtained after 7 and 28 days of curing. This experimental study shows that the concrete made with quarry dust might not be as workable as normal concrete but it gives higher strength than the conventional concrete. ...
There were in all mixes in each grade of concrete together with control mix and five mixes with quarry dust as a partial replacement of natural sand. It was experimental that with use of quarry dust at all replacement levels, the workability of concrete was abridged from 1-6%.
Sudhir S. Kapgate and S. R. Satone, Effect of quarry dust as partial replacement of sand in concrete Indian streams research journal, vol.3(5), 2013, ISSN 2230-7850. R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, Partial Replacement of Sand with Quarry Dust in Concrete. International Journal of …
The demand of natural sand in the construction industry has increased a lot resulting in the reduction of sources and an increase in price. Thus an increased need to identify a suitable substitute, that is eco-friendly and inexpensive quarry dust being extensively used as an alternative to the sand in the production of concrete. In this paper an attempt has been made …
To overcome this crisis, partial replacement of sand with quarry dust can be economic alternative. Therefore, construction industries of developing countries are in stress to identify alternative materials to replace the demand for natural …
Silica Fume as partial replacement of cement and Quarry Dust as partial replacement of natural sand and studied their effect on the performance of M25 concrete. 1. Materials and Methodolgy 1.1 Cement Cement: Ordinary Portland Cement 43 grade (OPC-43) confirming to IS 8112:1989. The cement used was of Ultratech Cement.
fine aggregates as natural sand and quarry dust, coarse aggregates and poly propylene fibres. Also this experiment deals with the study of partial replacement of natural sand by quarry dust and effect of change in water content ratio. Geo polymer requires a heat curing which is eliminated by adding Granulated
An Experimental Study on Quarry Dust as Partial Replacement for Sand in Concrete ABSTRACT- Concrete plays the key role and a large quantum of concrete is being utilized in …
In such a scenario the quarry dust will be a cheap different to stream sand. Stone dust or quarry dust is a waste material obtained from crusher plants. It has potential to be used as partial replacement of natural stream sand in concrete. Use of stone dust in concrete not only improves the quality of concrete
An Experimental study on Effects of Quarry Dust as Partial Replacement of sand in concrete. International Research Journal of Engineering and Technology (IRJET), Volume: 04 (Issue: 11). Shyam Prakash, K, & Rao, Ch. (2016). Study on compressive strength of quarry dust as fine aggregate in concrete. Advances in Civil Engineering, 2016.
In this experimental investigation cubes casted with partial replacement of cement by quarry dust with percentages 0%, 10%, 20%, 25%, 30%, and end up with 40%. M30 grade of ... sand and quarry dust," ARPN Journal of Engineering and Applied Sciences, vol. 7, pp. 324–331, 2012.
Hence the use of Bamboo and quarry dust as replacement for coarse aggregate and fine aggregate in concrete is reducing the Environmental wastes which pose a difficult problem in its disposal ...
The Dust contents higher than 15% increases the water absorption of the concrete. Partial replacement of sand by stone dust in concrete also reduces workability but the compressive strength and split tensile strength increase gradually up to 40% of sand replacement by stone dust (Shukla et al., 2000).
The objective of the present project work is to study the behavior of concrete in partial replacement for cement with quarry dust in proportions. Quarry dust a waste from the quarry processing ...
International Journal of Innovative Technology and Exploring Engineering (IJITEE) ISSN: 2278-3075, Volume-2, Issue-6, May 2013 Partial Replacement of Sand with Quarry Dust in Concrete Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao Abstract--The reduction in the sources of natural sand and the requirement for reduction in the …
replacement of sand with quarry dust. This experimental study presents the variation in the strength and durability propertie s of. concrete when replacing sand by quarry dust from 0% to 5 0% in ...
Lohani T.K., Padhi M., Dash K.P., Jena S. (2012) OPTIMUM UTILIZATION OF QUARRY DUST AS PARTIAL REPLACEMENT OF SAND IN CONCRETE Int. Journal of Applied Sciences and Engineering Research, Vol. 1, No. 2, 2012 6. Joseph 0. Ukpata, Maurice E. Ephraim and Godwin A. Akeke (JANUARY 2012 COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC …
Anzar Hamid Mir et.al., "Improved Concrete Properties Using Quarry Dust as Replacement for Natural Sand", International Journal of Engineering Research and Development, Vol. 11, issue 03, pp. 46 ...
river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.
to normal concrete and then decreases by 50%. For the replacement of sand with mine dust, the quantity of compressed power is determined for different percentage and grade of concrete. …
It was deduced from those studies that partial replacement of sand with quarry dust without the inclusion of other admixtures resulted in enhanced workability in the concrete mixes [2-3], but in a reduced compressive strength and durability [3-5]. Besides, Ho et al. [6] have also researched quarry dust for self-compacting concrete applications ...
Sarangapani and Anand V.R. (2011) have studied the effect of partial replacement of sand by quarry dust in plain cement concrete for different mix proportions. They have concluded that sand can be replaced effectively by means of quarry dust up to 20% to 25%. Shahul Hameed and Sekar (2009) deliberated the properties of green concrete containing ...
quarry dust concrete is 10-12% more along with durability under sulphate and acid action. It also shown that the water absorption property of this concrete is slightly higher and lastly they have conclude that the replacement of natural sand with quarry dust, as full replacement in concrete is possible. To decide the water content and mix ...